Loading AI tools
2007 plane crash in São Paulo, Brazil From Wikipedia, the free encyclopedia
TAM Airlines Flight 3054 (JJ3054/TAM3054) was a regularly scheduled domestic passenger flight operated by TAM Airlines from Porto Alegre to São Paulo, Brazil. On the evening of July 17, 2007, the Airbus A320-233 serving the flight overran runway 35L at São Paulo after touching down during moderate rain and crashed into a nearby TAM Express warehouse adjacent to a Shell gas station.[6][7] The aircraft exploded on impact, killing all 187 passengers and crew on board, as well as 12 people on the ground. An additional 27 people in the warehouse were injured.[2][8][9] The accident surpassed Gol Transportes Aéreos Flight 1907 as the deadliest aviation accident in Brazilian territory and in South American history and was the deadliest involving the Airbus A320 series until the bombing of Metrojet Flight 9268 in 2015, which killed 224. This was the last major fatal plane crash in Brazil that until 2024, when Voepass Linhas Aéreas Flight 2283 crashed near São Paulo which killed 62.
PR-MAZ, similar aircraft to the one involved | |
| Accident | |
|---|---|
| Date | July 17, 2007 |
| Summary | Crashed following runway overrun due to pilot error |
| Site | São Paulo–Congonhas Airport, São Paulo, Brazil 23°37′11″S 046°39′44″W |
| Total fatalities | 199 |
| Total injuries | 27 |
| Aircraft | |
| Aircraft type | Airbus A320-233 |
| Operator | TAM Airlines |
| IATA flight No. | JJ3054 |
| ICAO flight No. | TAM3054 |
| Call sign | TAM 3054 |
| Registration | PR-MBK[1] |
| Flight origin | Salgado Filho International Airport, Porto Alegre, Brazil |
| Destination | São Paulo–Congonhas Airport, São Paulo, Brazil |
| Occupants | 187 |
| Passengers | 181[2][3] |
| Crew | 6[4] |
| Fatalities | 187[5] |
| Survivors | 0 |
| Ground casualties | |
| Ground fatalities | 12 |
| Ground injuries | 27 |
The accident was investigated by the Brazilian Air Force's Aeronautical Accidents Investigation and Prevention Center (Portuguese: Centro de Investigação e Prevenção de Acidentes Aeronáuticos; CENIPA), and a final report was issued in September 2009. CENIPA concluded that the accident was caused by pilot errors during the landing at São Paulo.
On both of Congonhas Airport's runways (35L/17R and 35R/17L), a slope prevented the drainage of accumulated water on the asphalt. The surface was already smooth due to the excess rubber caused by tire pressure during landing.[10] There were no runway end safety areas, as Avenida Washington Luís (a busy avenue), as well as several buildings and houses, were located at the end of runways 35L and 35R. On July 24, 2006, less than a year before the accident, a Boeing 737 of BRA Transportes Aéreos had difficulty stopping on runway 35L, but the pilots were able to bring the aircraft to a stop safely by performing a ground loop.[11] Due to delays and flight cancellations caused by rains in early 2007, Infraero (the company that manages Congonhas Airport) decided to resurface the airport's main runway. The installation of channeling grooves was planned to reduce the risk of hydroplaning.[12][11] The resurfacing work was completed on June 29, but the grooves were not added. Infraero stated that adding the grooves would require an additional 30 days. Despite the incomplete refit, the Congonhas runway remained open for use during the 2006–07 Brazilian aviation crisis.[11]
On July 16, the day before the crash, four pilots who landed at the airport reported poor braking conditions, including a TAM pilot who managed to stop his aircraft just a few meters before the end of the runway. Between 12:25 pm and 12:28 pm, Infraero suspended operations at the airport to assess the runway conditions and subsequently cleared it for use, reporting "no puddles and water slides." However, at 12:42 local time on the same day, Pantanal Linhas Aéreas Flight 4763, an ATR 42-300, hydroplaned after touching down on runway 17R. The aircraft veered to the left, striking a concrete box and a small light pole before coming to rest on the grass between the runway and taxiway. All 25 people on board survived with no injuries, but the aircraft was severely damaged and deemed beyond repair.[13][14] Despite this incident, landings continued to be conducted normally at the airport.[15]
The aircraft operating as Flight 3054 was a twin turbofan Airbus A320-233, serial number 789, registration PR-MBK; it was powered by two IAE V2500 engines. It was built in 1998 and had been operated by other airlines before entering service with TAM in January 2007, six months before the accident. The aircraft was owned by Pegasus Aviation and had flown more than 21,000 hours over 10,000 cycles before the crash.[1]
The aircraft was dispatched with the thrust reverser on the starboard engine deactivated, as it had jammed. TAM said in a statement that a fault in a reverser "does not jeopardize landings" and no mechanical problem had been recorded on July 16, the day before the accident.[16] The aircraft had no difficulty braking on the same runway a day before the fatal accident.[17]
There were six crew members and 181 passengers on board. All 6 crew members as well as 171 of the passengers were Brazilian; the 10 remaining passengers were of various other nationalities.[18] The flight crew consisted of two captains (rather than the usual captain and first officer): Captain Henrique Stefanini Di Sacco (53), and Captain Kleyber Aguiar Lima (54).[19] There were also four flight attendants, with an additional 13 deadheading. Both pilots had been flying for over 30 years. Stefanini had logged 13,654 flight hours in his career (including 2,236 hours on the Airbus A320), and Lima 14,760 hours, with 237 of them on the Airbus A320.[19]
| Nationality | Passengers | Crew | Ground | Total |
|---|---|---|---|---|
| Brazil | 171 | 6 | 12 | 189 |
| France | 2 | 0 | 0 | 2 |
| Argentina | 2 | 0 | 0 | 2 |
| Portugal | 1 | 0 | 0 | 1 |
| Sweden | 1 | 0 | 0 | 1 |
| United States | 1 | 0 | 0 | 1 |
| South Africa | 2 | 0 | 0 | 2 |
| Peru | 1 | 0 | 0 | 1 |
| Total | 181 | 6 | 12 | 199 |
Several players and coaches from the Grêmio football club were initially booked on Flight 3054, intending to catch a connecting flight in Congonhas and fly to Goiânia, for a game scheduled against the Goiás Esporte Clube. However, the club's management rescheduled the trip to the next day.[20] The plane departed from Salgado Filho International Airport in Porto Alegre at 17:18 Brazilian Standard Time (BRT) (20:18 UTC). It climbed to flight level (FL) 340 (34,000 feet (10,000 m)).[21] At 18:48 BRT (21:48 UTC), the flight made its landing at Congonhas-São Paulo Regional Airport.[21]
Flight 3054 was cleared to land at Congonhas's Runway 35L. Reviews by government officials of the surveillance videos showed that despite the aircraft touching down without incident, it did not slow down normally, veering to the left as it departed the far end at around 90 knots (170 km/h; 100 mph).[22] The runway is elevated above the surrounding area, and the aircraft's momentum carried it over traffic on the adjacent Avenida Washington Luís, a major thoroughfare, and crushed a four-story TAM Express facility, resulting in a large fire. The TAM Express facility contained offices and a warehouse, and was located adjacent to a Shell gas station. All 187 passengers and crew aboard died and the aircraft was destroyed.[23]
The runway had recently been resurfaced, and did not yet have water-channeling grooves cut into it to reduce the danger of hydroplaning.[6]
Flight Data Recorder (FDR) information recovered after the crash and released by Brazilian authorities showed that immediately prior to touchdown, both thrust levers were in CL (or "climb") position, with engine power being governed by the flight computer's autothrottle system.[24] Two seconds prior to touchdown, an aural warning, "retard, retard", was issued by the flight's computer system, advising the pilots to retard the thrust lever to the recommended idle lever position. This would disengage the autothrottle, with engine power then governed directly by the thrust levers.
At the moment of touchdown, the spoiler lever was in the "ARMED" position.[24] According to the system logic of the A320's flight controls,[25] in order for the spoilers to automatically deploy upon touchdown, not only must the spoiler lever be in the "ARMED" position, but both thrust levers must be at or close to the "idle" position. The FDR transcript shows that immediately after the warning, the flight computer recorded the left thrust lever being retarded to the rear-most position, activating the thrust reverser on the left engine, while the right thrust lever (controlling the engine with the disabled thrust reverser) remained in the CL position. One theory put forth by CENIPA is that the pilots may not have noticed that the right engine remained at CL because the Airbus autothrottle system, unlike other aircraft manufacturers, does not automatically move the levers when the autothrust controller changes engine settings. Therefore, the pilots may have thought that the right engine was at idle power without realizing that Airbus autothrust logic dictates that, when one or more of the thrust levers is pulled to the idle position, the autothrust is automatically disengaged.[19] Thus, when the pilot pulled the left engine thrust lever to idle, it disconnected the autothrust system and the computer did not retard the right engine power to idle. The A320's spoilers did not deploy during the landing run, as the right thrust lever was above the "idle" setting required for automatic spoiler deployment.[24] Since the right engine thrust lever was still in the "climb" detent at that time, the right engine accelerated to climb power while the left engine deployed its thrust reverser. The resulting asymmetric thrust condition resulted in a loss of control and a crash ensued.
Source:[26]
| Time | Event | |
|---|---|---|
| UTC | Local time (UTC−03:00) | |
| 20:19 | 17:19 | Flight 3054 departs Salgado Filho Airport. |
| 21:20 | 18:20 | The flight begins its approach to Congonhas Airport. |
| 21:43 | 18:43 | The pilots perform the landing checklist. |
| 21:47 | 18:47 | Flight 3054 is cleared to land on runway 35L. |
| 21:48:24 | 18:48:24 | Thrust levers are positioned incorrectly. |
| 21:48:26 | 18:48:26 | Flight 3054 lands on the runway. |
| 21:48:30 | 18:48:30 | The aircraft begins to turn left. |
| 21:48:40 | 18:48:40 | The aircraft overshoots the runway. |
| 21:48:50 | 18:48:50 | The aircraft crashes into the TAM Express building. |
Aviation safety in Brazil had been under increased scrutiny following the mid-air collision in September 2006 over the Amazon of Gol Transportes Aéreos Flight 1907 and an Embraer Legacy 600 (see Brazil's 2006-2007 aviation crisis).
The 35L runway at Congonhas is 1,940 metres (6,360 ft) long. Congonhas's counterpart in Rio de Janeiro, the Santos Dumont Airport, has an even shorter runway, at 1,323 m (4,341 ft). Both airports receive the same type of traffic — ranging from small private planes to Boeing 737s and A320s. Many variables affect the landing distance of an aircraft, such as approach speed, weight and the presence of either a tailwind or a headwind. For an Airbus A320, a landing speed of 20 knots (37 km/h; 23 mph) higher than normal can result in as much as a 25% increase in the runway length needed to stop an aircraft. Wet weather can also significantly reduce the braking performance of aircraft, leading to an increase in the minimum runway length requirement.[27]
Pilots have called Congonhas airport the "aircraft carrier," because of the runway's short length and because pilots are told to go-around if they overshoot the first 1,000 feet (300 m) of runway.[28]
In June 2007, a Brazilian judge briefly banned flights using Fokker 100, Boeing 737-700 and Boeing 737-800 aircraft in and out of the airport. The Airbus A320 was not among the aircraft banned, due to its manufacturer-stated braking distance being shorter than those of the banned aircraft. Pilots had complained that water had been accumulating on the runway, reducing aircraft braking performance and occasionally causing planes to hydroplane.[29] The judge claimed the runway needed to be 388 metres (1,273 ft) longer for these aircraft to operate safely. At the time, a spokeswoman from Brazil's National Civil Aviation Agency claimed "The safety conditions of the runway and the airport as a whole are adequate."[30] TAM also objected to the decision, with a spokesman stating "If the injunction stands, it will cause total chaos," claiming over 10,000 passengers per day would be inconvenienced.[30]
The airport reopened on July 19, 2007, using an alternative runway.[17]
Many flights, including all OceanAir and BRA Transportes Aéreos, were transferred to Guarulhos International Airport, the major airport in São Paulo, due to the closure of the main runway at Congonhas and the ongoing investigation of the accident.[17]
On July 20, Presidency Chief of Staff Dilma Rousseff announced plans to significantly reduce the number of flights operating at Congonhas. The plan included banning, within 60 days, all connection, stopover, charter, and international flights and the reduction in the number of private jets. The airport would only operate direct flights to certain cities in Brazil. The plan also called for a study of the expansion of São Paulo's two current airports and the construction of a third airport in the metropolitan area.[31]
State crime scene investigators terminated the search for remains on July 28, 2007;[32] as of that date, 114 bodies recovered from the site had been identified by the São Paulo Medical Examiner's Office as those of passengers.[33]
The investigation was carried out by Brazil's Aeronautical Accidents Investigation and Prevention Center (Portuguese: Centro de Investigação e Prevenção de Acidentes Aeronáuticos; CENIPA). Data from the flight data recorder and cockpit voice recorder (CVR) were downloaded by the National Transportation Safety Board (NTSB) in the United States commencing July 20 and 23 respectively.[34][35] Based on preliminary data from the FDR, on July 25 Airbus cautioned A320 operators to ensure that both thrust levers are set to idle during flare.[34] The transcript of the CVR was released on August 1.[36] It shows that the pilots were aware of the wet runway conditions and the deactivated thrust reverser.[37] The pilots' comments suggest that the spoilers did not deploy and that they were unable to slow the aircraft.[37] Crew error had not been ruled out.[38]
An investigation[39] by the Brazilian Public Safety Ministry released in November 2008 concluded that the pilots mistakenly left the lever for the right engine to climb upon landing, due to a mistake in landing procedures with the right thrust reverser being disabled from a prior maintenance, when in fact it was necessary to retard both engines in order for the spoilers to work. They also said that the National Civil Aviation Agency should have closed the airport on the night the plane landed because of heavy rains; that Congonhas airport authorities shared the blame because its runway had not been properly constructed with grooves to drain away excess rainwater, contributing to the crash; that the plane's manufacturer, Airbus, should have provided alarms warning the pilots that the braking system was failing; and that TAM failed to properly train its pilots, who did not act correctly in the emergency.[40]
In September 2009, more than two years after the accident, CENIPA announced the results of official investigations. The report shows that one of the thrust levers, which control engines, was in position to accelerate when it should be in idle, but it was not proved if there was mechanical or human failure as the cause of the accident.[19][41][42]
The report suggests two hypotheses for the accident. In the first, there was a flaw in the power control of the plane's engines, which would have kept one of the thrust levers into acceleration, regardless of their actual position. This scenario would implicate mechanical failure of the aircraft as the cause of the accident. The likelihood of this failure occurring is calculated at once per 400 billion flight hours, and therefore highly improbable. In the second hypothesis, the pilot has performed a procedure different from that provided in the manual, and put the thrust lever in an irregular position. This scenario would implicate human error as the cause of the accident.[19]
In addition to the positions of the thrust levers, the report points to several factors that may have contributed to the accident, such as a high volume of rain on the day, with the formation of puddles on the runway, as well as the absence of grooving. The report does not blame the length of the runway for the accident. The BEA also cleared Airbus of any misdoing because they had proposed a system warning modification regarding the incorrect thrust lever positions that TAM had rejected.[19]
After the crash, President Luiz Inácio Lula da Silva ordered three days of national mourning.[43]
During the 2007 Pan American Games in Rio de Janeiro, the Brazilian athletes wore a black armband in remembrance of the victims.[44] The flags of all participating countries were flown at half mast on July 18. Matches involving a Brazilian athlete or team started with a minute of silence.[45]
All matches of the Campeonato Brasileiro 2007 started with a minute of silence, while all players wore black armbands.[46] Brazilian Formula One driver Felipe Massa had a black stripe on top of his helmet during the 2007 European Grand Prix, to commemorate the victims. Rubens Barrichello also had stripes on his helmet, and the two Red Bull Racing drivers David Coulthard and Mark Webber had small Brazilian flags on their helmets referring to the accident.[47]
More than 5,000 Brazilians marched to the crash site on July 29, 2007, blaming their government's failure to invest in airport infrastructure for the crash. Many of the protesters also demanded Lula's ouster.[48]
Argentina: President Néstor Kirchner called president Lula to express condolences.[49]
Chile: President Michelle Bachelet called president Lula to offer her condolences.[49]
China: President Hu Jintao expressed his condolences to the Brazilian government as well as the friends and families of the victims.[50]
Germany: President Horst Köhler sent a telegram to President Lula expressing his condolences to the families of the victims. According to a statement reported by the German embassy in Brasilia, Germany would join the three-day mourning by lowering the flag at half-mast at the embassy.[51]
Mexico: Former president Vicente Fox expressed his condolences.[52]
Peru: President Alan Garcia expressed his condolences and requested to talk with president Lula.[49]
Spain: Felipe VI of Spain was in Brazil at the time of the accident and expressed condolences.[53]
United States: President George W. Bush, his spokesman Sean McCormack, and secretary of state Condoleezza Rice all expressed their condolences. Rice also called Brazilian Foreign Minister Celso Amorim to express additional condolences.[49]
Vatican: Odilo Scherer, the Archbishop of São Paulo, received a telegram from Pope Benedict XVI signed by the Vatican's secretary of state Tarcisio Bertone, expressing condolences as well as a mass for the victims.[54]
Venezuela: Foreign minister Nicolás Maduro expressed his condolences to Brazil's government and citizens.[55]
On July 17, 2012, the fifth anniversary of the accident, a plaza named Memorial Square was opened. Memorial Square was built on the site of the TAM express warehouse (demolished on August 5, 2007), which is 8,318 square metres (89,530 sq ft) in area.[56] There is a memorial with the names of the victims engraved as well as a mulberry tree that survived the crash.[57] There is another memorial in Porto Alegre called "Largo da Vida," where 199 trees have been planted. The memorial is located near Salgado Filho International Airport (the airport from which Flight 3054 departed).[58]
On November 19, 2008, the 13,600-page police investigation was completed, which took 16 months of research to produce, during which 336 people were heard.[59] Federal prosecutors were of the opinion that the former director of the National Civil Aviation Agency (ANAC), Denise Abreu (who had taken up the post in March 2006), and the flight safety officer of the airline, Marco Aurelio dos Santos de Miranda, should both face criminal charges.[60] In 2011, the Brazilian Federal Public Ministry (Ministério Público Federal—MPF) laid criminal charges against Abreu and Miranda, as well as Alberto Fajerman, TAM's vice president of operations. They were accused of neglecting air transport safety by allowing the aircraft to land in heavy rain on the notoriously short, recently resurfaced runway before cutting of grooves to channel away excess rainwater. The trial began in São Paulo in 2013.[61] In 2014, MPF withdrew the charges against Fajerman, for lack of evidence.[62] A second charge against Abreu of "documentary falsehood" was dismissed in November 2014.[63] As of March 2015, no judgement had been handed down on the other charges.
In 2014, TAM's insurer Itaú Seguros, the company responsible for paying compensation for the tragedy, launched a lawsuit in Brazil against Airbus for R$350 million (US$156.2 million), according to Folha de S. Paulo. Attorneys representing Airbus responded in a Brazilian court filing that Airbus accepts no responsibility, laying the blame for the disaster with the cockpit crew, the airline and the poor state of the runway.[64]
Among the victims were:
The documentary television series Mayday, also known as Air Disasters, examined the crash and investigation in a Season 11 episode titled "Deadly Reputation" (and alternatively "Nightmare Runway" and "Disaster Runway"), which features interviews with investigators and a dramatic recreation of the accident.[29]
Seamless Wikipedia browsing. On steroids.
Every time you click a link to Wikipedia, Wiktionary or Wikiquote in your browser's search results, it will show the modern Wikiwand interface.
Wikiwand extension is a five stars, simple, with minimum permission required to keep your browsing private, safe and transparent.
