The Piper J-3 Cub is an American light aircraft that was built between 1938 and 1947 by Piper Aircraft. The aircraft has a simple, lightweight design which gives it good low-speed handling properties and short-field performance. The Cub is Piper Aircraft's most-produced model, with nearly 20,000 built in the United States. Its simplicity, affordability and popularity invokes comparisons to the Ford Model T automobile.
| J-3 Cub | |
|---|---|
.jpg) A former-military L-4H Grasshopper in 1990 | |
| General information | |
| Type | Trainer/light aircraft |
| National origin | United States |
| Manufacturer | Piper Aircraft |
| Designer | |
| Number built | 19,888 (US built)[1] 150 (Canadian-built)[1] 253 TG-8 gliders[1] |
| History | |
| Manufactured | 1938–1947 |
| First flight | 1938 |
| Developed from | Taylor Cub Taylor J-2 |
| Variants | PA-11 Cub Special PA-15 Vagabond PA-16 Clipper PA-18 Super Cub |
The aircraft is a high-wing, strut-braced monoplane with a large-area rectangular wing. It is most often powered by an air-cooled, flat-4 piston engine driving a fixed-pitch propeller. Its fuselage is a welded steel frame covered in fabric, seating two people in tandem.
The Cub was designed as a trainer. It had great popularity in this role and as a general aviation aircraft. Due to its performance, it was well suited for a variety of military uses such as reconnaissance, liaison and ground control. It was produced in large numbers during World War II as the L-4 Grasshopper. Many Cubs are still flying today. Cubs are highly prized as bush aircraft.
The aircraft's standard chrome yellow paint came to be known as "Cub Yellow" or "Lock Haven Yellow".[2]
Design and development
The Taylor E-2 Cub first appeared in 1930, built by Taylor Aircraft in Bradford, Pennsylvania. Sponsored by William T. Piper, a Bradford industrialist and investor, the affordable E-2 was meant to encourage greater interest in aviation. Later in 1930, the company went bankrupt, with Piper buying the assets, but keeping founder C. Gilbert Taylor on as president. In 1936, an earlier Cub was altered by employee Walter Jamouneau to become the J-2 while Taylor was on sick leave. Some believed the "J" stood for Jamouneau, while aviation historian Peter Bowers concluded the letter simply followed the E, F, G and H models, with the letter "I" skipped because it could be mistaken for the numeral "1".[3][4] When he saw the redesign, Taylor was so incensed that he fired Jamouneau. Piper, however, had encouraged Jamouneau's changes and hired him back. Piper then bought Taylor's share in the company, paying him $250 per month for three years. [5]
Although sales were initially slow, about 1,200 J-2s were produced before a fire in the Piper factory, a former silk mill in Bradford, Pennsylvania, ended its production in 1938. After Piper moved his company from Bradford to Lock Haven, Pennsylvania, the J-3, which featured further changes by Jamouneau, replaced the J-2. The changes integrated the vertical fin of the tail into the rear fuselage structure and covered it simultaneously with each of the fuselage's sides, changed the rearmost side window's shape to a smoothly curved half-oval outline and placed a steerable tailwheel at the rear end of the J-2's leaf spring-style tailskid, linked for its steering function to the lower end of the rudder with springs and lightweight chains to either end of a double-ended rudder control horn. Powered by a 40 hp (30 kW) engine, in 1938, it sold for just over $1,000.[6]
Several alternative air-cooled engines, typically flat-fours, powered the J-3 Cubs, designated J3C when using the Continental A series,[7] J3F using the Franklin 4AC,[8] and J3L with the Lycoming O-145.[9] Very few examples, designated J3P, were equipped with Lenape Papoose 3-cylinder radial engines.[10]
The outbreak of hostilities in Europe in 1939, along with the growing realization that the United States might soon be drawn into World War II, resulted in the formation of the Civilian Pilot Training Program (CPTP). The Piper J-3 Cub became the primary trainer aircraft of the CPTP and played an integral role in its success, achieving legendary status. About 75% of all new pilots in the CPTP (from a total of 435,165 graduates) were trained in Cubs. By war's end, 80% of all United States military pilots had received their initial flight training in Piper Cubs.[11]
The need for new pilots created an insatiable appetite for the Cub. In 1940, the year before the United States entered the war, 3,016 Cubs had been built. Wartime demands soon increased that production rate to one Cub being built every 20 minutes.[11]
Flitfire
Prior to the United States entering World War II, J-3s were part of a fund-raising program to support the United Kingdom. Billed as a Flitfire, a Piper Cub J3 bearing Royal Air Force insignia was donated by W. T. Piper and Franklin Motors to the RAF Benevolent Fund to be raffled off. Piper distributors nationwide were encouraged to do the same. On April 29, 1941, all 48 Flitfire aircraft, one for each of the 48 states that made up the country at that time, flew into La Guardia Field for a dedication and fundraising event which included Royal Navy officers from the battleship HMS Malaya, in New York for repairs, as honored guests.[12][13] At least three of the original Flitfires have been restored to their original silver-doped finish.[14]
Operational history
World War II service
Minutes before the 1941 Attack on Pearl Harbor, Machinist Mate 2nd Class Marcus F. Poston, a student pilot, was on a solo flight through K-T Flying Service, piloting a Piper Cub J-3 over the valley of Oahu. Poston was flying just as the Japanese planes began appearing over the island and was subsequently shot down. Poston managed to bail out and parachute to safety. The Piper J-3 Cub was the first American plane to be shot down in World War II.
The Piper Cub quickly became a familiar sight. First Lady Eleanor Roosevelt took a flight in a J-3 Cub, posing for a series of publicity photos to help promote the CPTP. Newsreels and newspapers of the era often featured images of wartime leaders, such as Generals Dwight Eisenhower, George Patton and George Marshall, flying around European battlefields in Piper Cubs.
Civilian-owned Cubs joined the war effort as part of the newly formed Civil Air Patrol, patrolling the Eastern Seaboard and Gulf Coast in a constant search for German U-boats and survivors of U-boat attacks.[15][self-published source?][16][17]
Piper developed a military variant ("All we had to do," Bill Jr. is quoted as saying, "was paint the Cub olive drab to produce a military airplane"),[5] variously designated as the O-59 (1941), L-4 (after April 1942) and NE (U.S. Navy). The L-4 Grasshopper was mechanically identical to the J-3 civilian Cub, but was distinguishable by the use of a Plexiglas greenhouse skylight and rear windows for improved visibility, much like the Taylorcraft L-2 and Aeronca L-3 also in use with the US armed forces. It had accommodations for a single passenger in addition to the pilot. When carrying only the pilot, the L-4 had a top speed of 85 mph (137 km/h), a cruise speed of 75 mph (121 km/h), a service ceiling of 12,000 ft (3,658 m), a stall speed of 38 mph (61 km/h), an endurance of three hours,[18] and a range of 225 mi (362 km).[19] Some 5,413 L-4s were produced for U.S. forces, including 250 built for the U.S. Navy under contract as the NE-1 and NE-2.[20][21]
All L-4 models, as well as similar, tandem-cockpit accommodation aircraft from Aeronca and Taylorcraft, were collectively nicknamed "Grasshoppers", though the L-4 was almost universally referred to by its civilian designation of Cub. The L-4 was used extensively in World War II for reconnaissance, transporting supplies, artillery spotting duties and medical evacuation of wounded soldiers.[11] During the Allied invasion of France in June 1944, the L-4's slow cruising speed and low-level maneuverability made it an ideal observation platform for spotting hidden German armor waiting in ambush in the hedgerowed bocage country south of the invasion beaches. For these operations, the pilot generally carried both an observer/radio operator and a 25-pound (11 kg) communications radio, a load that often exceeded the plane's specified weight capacity.[18] After the Allied breakout in France, L-4s were also sometimes equipped with improvised racks, usually in pairs or quartets, of infantry bazookas for ground attack (actually a form of top attack) against German armored units. The most famous of these L-4 ground attack planes was Rosie the Rocketer, piloted by Maj. Charles "Bazooka Charlie" Carpenter, whose six bazooka rocket launchers were credited with eliminating six enemy tanks and several armored cars during its wartime service,[22][23] especially during the Battle of Arracourt. L-4s could also be operated from ships, using the Brodie landing system.
After the war, many L-4s were sold as surplus, but a considerable number were retained in service.[24] L-4s sold as surplus in the U.S. were redesignated as J-3s, but often retained their wartime glazing and paint.[25]
Postwar
.jpg)
An icon of the era and of American general aviation, the J-3 Cub has long been loved by pilots and nonpilots alike, with thousands still in use. Piper sold 19,073 J-3s between 1938 and 1947, the majority of them L-4s and other military variants. After the war, thousands of Grasshoppers were civilian-registered under the designation J-3. Sixty-five pre-war Taylor and Piper Cubs were assembled from parts in Canada (by Cub Aircraft Corporation Ltd.). After the war, 130 J-3C-65 models were manufactured in Hamilton, Ontario. Sixteen L-4B models, (known as the Prospector), were later manufactured. The last J-3 model was assembled from parts at Leavens Bros. Toronto in 1952.[26] J-3 Cubs were also assembled in Denmark[27] and Argentina and by a licensee in Oklahoma.[28]
In the late 1940s, the J-3 was replaced by the Piper PA-11 Cub Special (1,500 produced), the first Piper Cub version to have a fully enclosed cowling for its powerplant and then the Piper PA-18 Super Cub, which Piper produced until 1981 when it sold the rights to WTA Inc. In all, Piper produced 2,650 Super Cubs. The Super Cub had a 150 hp (110 kW) engine which increased its top speed to 130 mph (210 km/h). Its range was 460 miles (740 km).
Korean War service
On 26 June 1950, one day after the Korean War broke out, the Republic of Korea Air Force flew L-4s to Dongducheon to support the ROK 7th Infantry Division against North Korean military by dropping two bombs from an observer in the rear seat. A total of 70 bombs were dropped until the following day, then aircraft were switched back to reconnaissance mission as bombs were depleted. South Korea lost 25 L-4s throughout the Korean War.[29]
The United States Army also operated small numbers of L-4s, but were replaced by L-16 during the war.[29] The L-4 was in service in many of the same roles it had performed during World War II, such as artillery spotting, forward air control and reconnaissance.[24] Some L-4s were fitted with a high-back canopy to carry a single stretcher for medical evacuation of wounded soldiers.[24]
Modern production
Modernized and up-engined versions are produced by Cub Crafters of Washington and by American Legend Aircraft in Texas, as the Cub continues to be sought after by bush pilots for its short takeoff and landing (STOL) capabilities, as well as by recreational pilots for its nostalgia appeal. The new aircraft are actually modeled on the PA-11, though the Legend company does sell an open-cowl version with the cylinder heads exposed, like the J-3 Cub. An electrical system is standard from both manufacturers.[citation needed]
The J-3 is distinguished from its successors by having a cowl that exposes its engine's cylinder heads — the exposed cylinders of any J-3's engine were usually fitted with sheet metal "eyebrow" air scoops to direct air over the cylinder's fins for more effective engine cooling in flight. Very few other examples exist of "flat" aircraft engine installations (as opposed to radial engines) in which the cylinder heads are exposed. From the PA-11 on through the present Super Cub models, the cowling surrounds the cylinder heads.[30]
A curiosity of the J-3 is that when it is flown solo, the lone pilot normally occupies the rear seat for proper balance, to balance the fuel tank located at the firewall. Starting with the PA-11, as well as some L-4s, fuel was carried in wing tanks, allowing the pilot to fly solo from the front seat.[30]
Variants
Civil
- J-3
- Equipped with a Continental A-40, A-40-2, or A-40-3 engine of 37 hp (28 kW), or A-40-4 engine of 40 hp (30 kW)[31]
- J3C-40
- Certified 14 July 1938 and equipped with a Continental A-40-4 or A-40-5 of 40 hp (30 kW)[7]
- J3C-50
- Certified 14 July 1938 and equipped with a Continental A-50-1 or A-50-2 to -9 (inclusive) of 50 hp (37 kW)[7]
- J3C-50S
- Certified 14 July 1938 and equipped with a Continental A-50-1 or A-50-2 to -9 (inclusive) of 50 hp (37 kW), equipped with optional float kit[7]
- J3C-65
- Certified 6 July 1939 and equipped with a Continental A-65-1 or A-65-3, 6, 7, 8, 8F, 9 or 14 of 65 hp (48 kW) or an A-65-14, Continental A-75-8, A-75-8-9 or A-75-12 of 75 hp (56 kW) or Continental C-85-8 or C-85-12 of 85 hp (63 kW) or Continental C-90-8F of 90 hp (67 kW)[7]
- J3C-65S
- Certified 27 May 1940 and equipped with a Continental A-65-1 or A-65-3, 6, 7, 8, 8F, 9 or 14 of 65 hp (48 kW) or an A-65-14, Continental A-75-8, A-75-8-9 or A-75-12 of 75 hp (56 kW) or Continental C-85-8 or C-85-12 of 85 hp (63 kW) or Continental C-90-8F of 90 hp (67 kW), equipped with optional float kit[7]
- J3F-50
- Certified 14 July 1938 and equipped with a Franklin 4AC-150 Series 50 of 50 hp (37 kW)[8]
- J3F-50S
- Certified 14 July 1938 and equipped with a Franklin 4AC-150 Series 50 of 50 hp (37 kW), equipped with optional float kit[8]
- J3F-60
- Certified 13 April 1940 and equipped with a Franklin 4AC-150 Series A of 65 hp (48 kW) or a Franklin 4AC-171 of 60 hp (45 kW)[8]
- J3F-60S
- Certified 31 May 1940 and equipped with a Franklin 4AC-150 Series A of 65 hp (48 kW) or a Franklin 4AC-171 of 60 hp (45 kW), equipped with optional float kit[8]
- J3F-65
- Certified 7 August 1940 and equipped with a Franklin 4AC-176-B2 or a Franklin 4AC-176-BA2 of 65 hp (48 kW)[8]
- J3F-65S
- Certified 4 January 1943 and equipped with a Franklin 4AC-176-B2 or a Franklin 4AC-176-BA2 of 65 hp (48 kW), equipped with optional float kit[8]
- J3L
- Certified 17 September 1938 and equipped with a Lycoming O-145-A1 of 50 hp (37 kW) or a Lycoming O-145-A2 or A3 of 55 hp (41 kW)[9]
- J3L-S
- Certified 2 May 1939 and equipped with a Lycoming O-145-A1 of 50 hp (37 kW) or a Lycoming O-145-A2 or A3 of 55 hp (41 kW), equipped with optional float kit[9]
- J3L-65
- Certified 27 May 1940 and equipped with a Lycoming O-145-B1, B2, or B3 of 65 hp (48 kW)[9]
- J3L-65S
- Certified 27 May 1940 and equipped with a Lycoming O-145-B1, B2, or B3 of 65 hp (48 kW), equipped with optional float kit[9]
- J3P
- Variant powered by a 50 hp (37 kW) Lenape LM-3-50 or Lenape AR-3-160 three-cylinder radial engine[1][10]
- J-3R
- Variant with slotted flaps powered by a 65 hp (48 kW) Lenape LM-3-65 engine.[1]
- J-3X
- 1944 variant with cantilever wing powered by a 65 hp (48 kW) Continental A-65-8 engine.[1]
- L-4B Prospector
- Canadian manufactured model, with removable rear seat and control, additional capacity, optional extra fuel tank and painted in a PA-12 color scheme.[32]
- Cammandre 1
- A French conversion of J-3 Cub/L-4 aircraft[33]
- Poullin J.5A
- Five L-4 Cubs converted by Jean Poullin for specialist tasks.[34]
- Poullin J.5B
- A single L-4 Cub converted by Jean Poullin for specialist tasks[34]
- Wagner Twin Cub
- A twin fuselage conversion of the J-3[35]
Military
- YO-59
- Four US Army Air Corps test and evaluation J3C-65[36]
- O-59
- Production version for the USAAC; 140 built later redesignated L-4[36]
- O-59A
- Improved version, powered by a 65-hp (48-kW) Continental O-170-3 piston engine; 948 built, later redesignated L-4A[36]
- L-4
- Redesignated YO-59 and O-59[37]
- L-4A
- Redesignated O-59A.[37]
- L-4B
- As per L-4A, but without radio equipment; 980 built[37]
- L-4C
- Eight impressed J3L-65s, first two originally designated UC-83A[37]
- L-4D
- Five impressed J3F-65s[37]
- L-4H
- As per L-4B but with improved equipment and fixed-pitch propeller, 1801 built[37]
- L-4J
- L-4H with controllable-pitch propeller, 1680 built[37]
- UC-83A
- Two impressed J3L-65s, later redesignated L-4C[38]
Operators
Civil
The aircraft has been popular with flying schools — especially from the pre-World War II existence of the Civilian Pilot Training Program using them in the United States — and remains so with private individuals, into the 21st century.
Military
- Republic of Korea Air Force: Received 10 L-4s from the Army to create the Air Force in 1 October 1949. 8 L-4s were operational at the beginning of the Korean War. Lost 25 vehicles during the war.[29][43]
- Military of Paraguay - L-4[44]
Specifications (J3C-65 Cub)
Data from The Piper Cub Story[47]
General characteristics
- Crew: one pilot
- Capacity: one passenger
- Useful load: 455 lb (205 kg)
- Length: 22 ft 5 in (6.83 m)
- Wingspan: 35 ft 3 in (10.74 m)
- Height: 6 ft 8 in (2.03 m)
- Wing area: 178.5 sq ft (16.58 m2)
- Empty weight: 765 lb (345 kg)
- Max takeoff weight: 1,220 lb (550 kg)
- Powerplant: 1 × Continental A-65-8 air-cooled horizontally opposed four cylinder, 65 hp (48 kW) at 2,350 rpm
Performance
- Maximum speed: 76 kn (87 mph, 140 km/h)
- Cruise speed: 65 kn (75 mph, 121 km/h)
- Stall speed: 33 kn (38 mph, 61 km/h)
- Range: 191 nmi (220 mi, 354 km)
- Service ceiling: 11,500 ft (3,500 m)
- Rate of climb: 450 ft/min (2.3 m/s)
- Wing loading: 6.84 lb/sq ft (33.4 kg/m2)
- Power/mass: 18.75 lb/hp (11.35 kg/kW)
See also
Related development
- American Legend AL3C-100
- CubCrafters CC11-100 Sport Cub S2
- LIPNUR Belalang
- Marawing 1-L Malamut
- Piper J-2
- Piper PA-15 Vagabond
- Piper PA-16 Clipper
- Piper PA-18 Super Cub
- Piper PA-20 Pacer
- Wag-Aero CUBy
Aircraft of comparable role, configuration, and era
- Aeronca Champion
- Aeronca L-3
- American Eagle Eaglet
- Fieseler Fi 156 Storch
- Kitfox Model 5
- Taylorcraft BC-65
- Taylorcraft L-2
Related lists
References
Bibliography
External links
Wikiwand in your browser!
Seamless Wikipedia browsing. On steroids.
Every time you click a link to Wikipedia, Wiktionary or Wikiquote in your browser's search results, it will show the modern Wikiwand interface.
Wikiwand extension is a five stars, simple, with minimum permission required to keep your browsing private, safe and transparent.
